Fresher Under Pressure Scientific Research

FRUITS AND VEGETABLES

---

Evaluation of batch and semicontinuous application of high hydrostatic pressure on foodborne pathogens in salsa.

EV Raghubeer, CP Dunne, DF Farkas, EY Ting
Journal of Food Protection 2000 Dec;63(12):1713-8.

Abstract
The effects of high hydrostatic pressure (HPP; 545 MPa) on strains of Escherichia coli O157:H7, Listeria monocytogenes, enterotoxigenic Staphylococcus aureus, and nonpathogenic microorganisms were studied in tomato-based salsa. Products were evaluated for the survival of the inoculated pathogens following HPP treatment and after storage at 4 degrees C and 21 to 23 degrees C for up to 2 months. Inoculated samples without HPP treatment, stored under the same conditions, were also evaluated to determine the effects of the acid environment of salsa on the survival of inoculated strains. None of the inoculated pathogens were detected in the HPP-treated samples for all treatments throughout the storage period. Inoculated pathogens were detected in the non-HPP-treated samples stored at 4 degrees C after 1 month, with L. monocytogenes showing the highest level of survivors. In the non-HPP-treated samples stored at 21 to 23 degrees C, E. coli and S. aureus were not detected after 1 week, but L. monocytogenes was detected in low levels. Studies with nonpathogenic strains of the pathogens were conducted at Oregon State University using HPP treatments in a semicontinuous production system. The nonpathogenic microorganisms (E. coli, Listeria innocua, Listeria welshimeri, and nonenterotoxigenic S. aureus) were inoculated together into a feeder tank containing 100 liters of salsa. Microbiological results of samples collected before HPP treatment and from the aseptic filler were similar to those obtained for the pathogenic strains. No survivors were detected in any of the HPP-treated samples.

Effect of High Hydrostatic Pressure on Cryptosporidium parvum Infectivity

TR Slifko, E Raghubeer, and JB Rose
Journal of Food Protection: Vol. 63, No. 9, pp. 1262–1267.

Abstract
The incidence of foodborne disease outbreaks caused by contaminated low-pH fruit juices is increasing. With recent mandatory pasteurization of apple juice and the industry’s concerns of food safety, fruit juice processors are showing more interest in alternative nonthermal technologies that can kill >99.99% of microbial pathogens present in foods. The association of the coccidian protozoan, Cryptosporidium, with diarrheal disease outbreaks from contaminated tap water and fruit juice raises a safety concern in the food and beverage industries. The objective of this study was to evaluate the effects of high hydrostatic pressure (HHP) on C. parvum oocysts. Oocysts were suspended in apple and orange juice and HHP treated at 5.5 × 108 Pa (80,000 psi) for 0, 30, 45, 60, 90, and 120 s. Oocyst viability was assessed by excystation using bile salts and trypsin while the cell culture foci detection method was used to assess infectivity. Results indicated that HHP inactivated C. parvum oocysts by at least 3.4 log10 after 30 s of treatment. No infectivity was detected in samples exposed to 60 s of HHP and >99.995% inactivation was observed. This study demonstrated that HHP efficiently rendered the oocysts nonviable and noninfectious after treatment at 5.5 × 108 Pa.